SECTION I - PRODUCT IDENTIFICATION
Product Name: WBG/S3-4, WBG/S3-32, WBG/S3-G WATERBASE SPRAY GRAIN TEXTURE
Revision: 03/05/1987
SECTION II - HAZARDOUS INGREDIENTS & OTHER COMPONENTS
INGREDIENT CHEMICAL NAME |
OSHA PEL |
ACGIH TLV |
OTHER LIMITS RECOMMENDED |
CAS NUMBER |
1-methyl-2-Pyrrolisinone: N-Methyl Pyrrolidone |
100 ppm |
NE |
N/A |
872-50-4 |
N,N-Dirthylethanamine: Triethylamine |
25 ppm |
10 ppm |
N/A |
121-44-8 |
SECTION III – PHYSICAL DATA / CONTENTS WITHOUT PROPELLENT
|
BOILING POINT: |
-192-396°F |
SPECIFIC GRAVITY (H2O=1): |
N/A |
||||||
|
VAPOR PRESSURE (mm Hg): |
N/A |
MELTING POINT: |
N/A |
||||||
|
VAPOR DENSITY (AIR = 1): |
Heavier than air |
EVAPORATION RATE (Butyl Acetate = 1): |
Slower than ether |
||||||
|
SOLUBILITY IN WATER: |
N/A |
APPEARANCE AND ODOR: |
N/A |
||||||
SECTION IV: FIRE AND EXPLOSION HAZARD DATA
|
FLASH POINT (METHOD USED): |
Over 200°F PMCC |
|
FLAMMABLE LIMITS |
LEL: 1.2% |
|
EXTINGUISHING MEDIA: |
WATER FOG x |
STANDARD FOAM |
CO2 x |
|
DRY CHEMICAL x |
HALON |
|
UNUSUAL FIRE AND EXPLOSION HAZARDS: |
The material will not support combustion unless the water has evaporated. |
|
SPECIAL PRECAUTIONARY STATEMENTS: |
Water may be used to cool closed containers, to prevent pressure build-up. |
SECTION V: REACTIVITY DATA
|
STABILITY: |
x Stable Unstable |
|
Incompatibility : |
Strong oxidizers. |
|
Hazardous Decomposition: |
Normal combustion products including carbon dioxide, carbon monoxide, oxides of nitrogen. |
|
HAZARDOUS POLYMERIZATION: |
May Occur xWill not occur |
|
Conditions to Avoid: |
None known. |
SECTION VI: HEALTH HAZARD DATA
ROUTES OF ENTRY & HEALTH HAZARDS (ACUTE AND CHRONIC)
|
INGESTION: |
May be harmful if swallowed. |
|
EYES: |
May cause severe irritation. |
|
INHALATION: |
May cause irritation to nose, throat or lungs. |
|
SKIN: |
May cause irritation. |
EMERGENCY AND FIRST AID PROCEDURES
|
INGESTION: |
Consult physician. |
|
EYES: |
Flush immediately with copious quantities of running water for at least 15 minutes. |
|
INHALATION: |
Remove to fresh air. |
|
SKIN: |
Wash affected areas with soap and water. |
SECTION VII: PRECAUTIONS FOR SAFE HANDLING AND USE
|
STEPS TO BE TAKEN IN CASE LARGE AMOUNTS ARE RELEASED: |
Remove with inert absorbent. Ventilate area. Remove sources of spark or flame. |
|
WASTE DISPOSAL METHOD: |
Dispose in accordance with local, state, and federal regulation. This product is not a hazardous waste under RCRA Regulations (40 CFR 261). |
|
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE: |
Do not get in eyes. |
|
OTHER PRECAUTIONS: |
Do not take internally. Do not take internally. Avoid prolonged or repeated contact with skin. Avoid breathing vapors. |
SECTION VIII: CONTROL MEASURES
|
RESPIRATORY PROTECTION: |
If spray mists are generated, wear HIOSH approved particulate respirator. |
|
VENTILATION: |
Sufficient to keep vapor concentrate below limits in Section II. |
|
LOCAL EXHAUST: |
N/A |
|
PROTECTIVE GLOVES: |
Protective gloves required for direct contact. |
|
EYE PROTECTION: |
Safety goggles. |
SECTION IX: SPECIAL PRECAUTIONS
|
HEALTH: 2 |
HAZARD RATING KEY |
|
FLAMMABILITY: 1 |
0 = MINIMAL |
|
REACTIVITY: 0 |
1 = SLIGHT |
|
PERSONALPROTECTION: |
2 = MODERATE |
|
3 = SERIOUS |
|
|
4 = SEVERE |
|
|
* = CHRONIC HEALTH EFFECTS |
Disclaimer: The information contained herein is based on the data available to us and is believed to be accurate. However, no warranty is expressed or implied regarding the accuracy of this data or the results to be obtained from the use thereof. We assume no responsibility for injuries from the use of the product described herein.
